John Deere Electric Clutch Adjustment

Too much vibration debris on mower deck or in sheaves.

John deere electric clutch adjustment. I attached some images from the manual. Spindle brake needs adjustment. Lawn mower craftsman zts 7500. Damaged sheaves or sheaves out of alignment.

Many lawn tractors particularly john deere riding mowers use a pto clutch. The pto works off of a 12 volt system. Once the air gap is within the specified range engage the clutch at full coil voltage and rotate it. Blades out of balance.

Electric mower clutch for john deere l120 l130 gy20878 with repair tool kit deere for with electric repair clutch john gy20878 kit l120 l130 tool mower. Most john deere lawn mowers are equipped with an electric pto power take off. Pre jde 61 clutch adjusting tool john deere 3010 3020 4010 4020 4520 tractors tool adjusting pre jde 61 clutch 3020 deere tractors 4010 4020 3010 john 4520. If the wiring does not reveal any problem and a clutch adjustment does not resolve it it may be time to replace the clutch.

The electric clutch is operated by a switch located on the dashboard of the lawn mower. Damaged drive belt. The mower s battery sparks the pto clutch which then guides the shaft and rotates the blades of the mower. The clutch has a pulley underneath it with a belt that goes back to the mower deck.

However if there is any contact with the brake shroud the gap adjustment nuts should be backed off slightly to eliminate the contact. Mower blade engagement rod needs adjustment. The first and most common is a mechanical system a pulley that slides into position by a lever which creates tension on the mower deck belt and causes the blades to turn. Chris first try to adjust the clutch.

The electric clutch on a john deere lawn mower is responsible for the blades engaging on the mower deck. There are different types of drive systems for john deere lawn mowers. When the clutch is turned to the on position it engages a brake that turns the pulley allowing the blades to turn. Also check mower deck will not lower hope this helps good luck.

If there is no contact on the brake shroud the clutch is okay. The pto is the mechanism that turns on the blades located under the mower deck. Check blade timing and adjust timing belt tension if necessary.